We have a test case as follow:
mdadm -CR /dev/md1 -l 1 -n 4 /dev/sd[a-d] --assume-clean --bitmap=internal
mdadm -S /dev/md1
mdadm -A /dev/md1 /dev/sd[b-c] --run --force
mdadm --zero /dev/sda
mdadm /dev/md1 -a /dev/sda
echo offline > /sys/block/sdc/device/state
echo offline > /sys/block/sdb/device/state
sleep 5
mdadm -S /dev/md1
echo running > /sys/block/sdb/device/state
echo running > /sys/block/sdc/device/state
mdadm -A /dev/md1 /dev/sd[a-c] --run --force
When we readd /dev/sda to the array, it started to do recovery.
After offline the other two disks in md1, the recovery have
been interrupted and superblock update info cannot be written
to the offline disks. While the spare disk (/dev/sda) can continue
to update superblock info.
After stopping the array and assemble it, we found the array
run fail, with the follow kernel message:
[ 172.986064] md: kicking non-fresh sdb from array!
[ 173.004210] md: kicking non-fresh sdc from array!
[ 173.022383] md/raid1:md1: active with 0 out of 4 mirrors
[ 173.022406] md1: failed to create bitmap (-5)
[ 173.023466] md: md1 stopped.
Since both sdb and sdc have the value of 'sb->events' smaller than
that in sda, they have been kicked from the array. However, the only
remained disk sda is in 'spare' state before stop and it cannot be
added to conf->mirrors[] array. In the end, raid array assemble and run fail.
In fact, we can use the older disk sdb or sdc to assemble the array.
That means we should not choose the 'spare' disk as the fresh disk in
analyze_sbs().
To fix the problem, we do not compare superblock events when it is
a spare disk, as same as validate_super.
Signed-off-by: Yufen Yu <yuyufen@xxxxxxxxxx>
v1->v2:
fix wrong return value in super_90_load
---
drivers/md/md.c | 44 ++++++++++++++++++++++++--------------------
1 file changed, 24 insertions(+), 20 deletions(-)
diff --git a/drivers/md/md.c b/drivers/md/md.c
index 1be7abeb24fd..0a91c20071b3 100644
--- a/drivers/md/md.c
+++ b/drivers/md/md.c
@@ -1097,7 +1097,7 @@ static int super_90_load(struct md_rdev *rdev, struct md_rdev *refdev, int minor
{
char b[BDEVNAME_SIZE], b2[BDEVNAME_SIZE];
mdp_super_t *sb;
- int ret;
+ int ret = 0;
/*
* Calculate the position of the superblock (512byte sectors),
@@ -1111,14 +1111,12 @@ static int super_90_load(struct md_rdev *rdev, struct md_rdev *refdev, int minor
if (ret)
return ret;
- ret = -EINVAL;
-
bdevname(rdev->bdev, b);
sb = page_address(rdev->sb_page);
if (sb->md_magic != MD_SB_MAGIC) {
pr_warn("md: invalid raid superblock magic on %s\n", b);
- goto abort;
+ return -EINVAL;
}
if (sb->major_version != 0 ||
@@ -1126,15 +1124,15 @@ static int super_90_load(struct md_rdev *rdev, struct md_rdev *refdev, int minor
sb->minor_version > 91) {
pr_warn("Bad version number %d.%d on %s\n",
sb->major_version, sb->minor_version, b);
- goto abort;
+ return -EINVAL;
}
if (sb->raid_disks <= 0)
- goto abort;
+ return -EINVAL;
if (md_csum_fold(calc_sb_csum(sb)) != md_csum_fold(sb->sb_csum)) {
pr_warn("md: invalid superblock checksum on %s\n", b);
- goto abort;
+ return -EINVAL;
}
rdev->preferred_minor = sb->md_minor;
@@ -1156,19 +1154,22 @@ static int super_90_load(struct md_rdev *rdev, struct md_rdev *refdev, int minor
if (!md_uuid_equal(refsb, sb)) {
pr_warn("md: %s has different UUID to %s\n",
b, bdevname(refdev->bdev,b2));
- goto abort;
+ return -EINVAL;
}
if (!md_sb_equal(refsb, sb)) {
pr_warn("md: %s has same UUID but different superblock to %s\n",
b, bdevname(refdev->bdev, b2));
- goto abort;
+ return -EINVAL;
}
ev1 = md_event(sb);
ev2 = md_event(refsb);
- if (ev1 > ev2)
- ret = 1;
- else
- ret = 0;
+
+ /* Insist on good event counter while assembling, except
+ * for spares (which don't need an event count) */
+ if (sb->disks[rdev->desc_nr].state & (
+ (1<<MD_DISK_SYNC) | (1 << MD_DISK_ACTIVE)))
+ if (ev1 > ev2)
+ ret = 1;
}
rdev->sectors = rdev->sb_start;
/* Limit to 4TB as metadata cannot record more than that.
@@ -1180,9 +1181,8 @@ static int super_90_load(struct md_rdev *rdev, struct md_rdev *refdev, int minor
if (rdev->sectors < ((sector_t)sb->size) * 2 && sb->level >= 1)
/* "this cannot possibly happen" ... */
- ret = -EINVAL;
+ return -EINVAL;
- abort:
return ret;
}
@@ -1520,7 +1520,7 @@ static __le32 calc_sb_1_csum(struct mdp_superblock_1 *sb)
static int super_1_load(struct md_rdev *rdev, struct md_rdev *refdev, int minor_version)
{
struct mdp_superblock_1 *sb;
- int ret;
+ int ret = 0;
sector_t sb_start;
sector_t sectors;
char b[BDEVNAME_SIZE], b2[BDEVNAME_SIZE];
@@ -1676,10 +1676,14 @@ static int super_1_load(struct md_rdev *rdev, struct md_rdev *refdev, int minor_
ev1 = le64_to_cpu(sb->events);
ev2 = le64_to_cpu(refsb->events);
- if (ev1 > ev2)
- ret = 1;
- else
- ret = 0;
+ /* Insist of good event counter while assembling, except for
+ * spares (which don't need an event count) */
+ if (rdev->desc_nr >= 0 &&
+ rdev->desc_nr < le32_to_cpu(sb->max_dev) &&
+ (le16_to_cpu(sb->dev_roles[rdev->desc_nr]) < MD_DISK_ROLE_MAX ||
+ le16_to_cpu(sb->dev_roles[rdev->desc_nr]) == MD_DISK_ROLE_JOURNAL))
+ if (ev1 > ev2)
+ ret = 1;
}
if (minor_version) {
sectors = (i_size_read(rdev->bdev->bd_inode) >> 9);
--
2.17.2
